• How to find the VIN number?

The VIN number is stamped on the frame near the driver's seat.

• What is the distance between the pedals and the seat?
The driver's seat is adjustable to a maximum distance of 17 inches.

• I cannot get it to crank.
Check for gas.  Check for any lose wires.  Check for spark at the plug. If it does not help, and you have been through the trouble shooting chart in your owner's manual, give us a call at 1-877-855-0196.

• It always wants to go because it idles high.
Adjust down the idle screw on the carburetor. 

• My brakes don't work when I press the pedal.
Check for worn pads.  Check for debris on pads, rotor clipper, etc... Check brake fluid, check brake linkage.  Check brake pads.

• I smell gas when I ride.
Check for gas leakage at gas cap, petcock, fuel line and carburetor.  Do not crank with leaking gas present.

• What kind of oil should I use?
SF-SG SAE 10W40 motor oil. CAUTION: Add oil and measure from the front filler only.

• What kind of gas should I use?
The higher octane used, the better service you can expect.

• Can I ride the FireFox on pavement or on a side walk?
This vehicle is designed for off-road use only.

• I ran through some water and it will not run now.
Assuming the engine was not submerged, dry out the engine, electrical components and air filter.  Try and restart.

• Is it OK to wash the engine?
Stay away from the electrical components, air filter inlet, and fan shroud opening.

• My seat will not adjust.
There is debris and/or sand or dust.   Clean and lube seat slides, try again.  The passenger seat is not adjustable.

• My tire keeps going flat.
Check valve core, or for damaged valve stem.  Inflate tire and soak in soapy water.  It is a tubeless tire, if a leak is located, it can be plugged.

• Can I adjust something to make it go faster?
No.

• Does it need transmission fluid?
No.

• I put in too much oil, what to do?
Drain out the excess oil through the oil drain.  Check your dipstick again later.

• What areas should I keep oiled and lubed?
Cables, steering shaft, chain, seat adjuster. 

• How long will my brakes last?
This will depend on driving conditions, check for wear on a regular basis.

• How much weight can I tow?
This vehicle is not designed to tow. 

• What is the weight capacity of the Go-kart?
The maximum combined weight for driver and passenger is 400 pounds.

• How old should an operator be to drive the Kart?
Recommended minimum age is 16 years.

• My seatbelt will not latch.
Inspect for debris and clean as needed.  If this does not remedy the situation, replace the seat belt.

• Should I wear a helmet when I drive the FireFox?
Yes, at all times.  Read requirements in your owner's manual.

• There is water in my gas tank, I put oil in my gas tank.
The entire fuel system needs to be drained and cleaned.

• My engine backfires a lot when I am riding.
It could be fouled spark plugs, loose wire connections, valves out of adjustment, or the carburetor float out of adjustment.

• Is my engine four stroke or two stroke, and who makes it?
The engine is a Mistubishi four stroke.

• How much horsepower does the 620 have?
6.0HP

• How often should I change my spark plugs?
When plugs become fouled, or stop firing, or when periodic maintenance calls for it. 

• How do I put the chain back on?
Loosen the chain adjustment assembly on the back of the engine.  You may have to remove the chain guard.  Adjust to correct tension and retighten.

• My exhaust is loose.
Check manifold bolts.  Tighten as needed.

• It idles real rough.
Things to check: fouled plug, contaminated fuel, loose wire connections, valve clearance.

• It is real hard to crank.
Things to check: fouled plug, choke circuit malfunction, bad or old gas.

• Will the brush guard protect me if I roll over?
This is not rollover protection.  Avoid riding across slopes or turning sharply at excessive speeds.  Always wear safety restraints and protective gear such as helmets and gloves.   In case of rollover, keep hands and arms inside of Kart.

BACK TO TOP